新聞資訊
GH4169合金δ相的溶解行為及對變形機制的影響
發布人：上海艾荔艾金屬材料有限公司m.85978597.cn
更新時間：2015-11-02
采用光學顯微鏡(OM)、掃描電鏡(SEM)、電子背散射衍射(EBSD)技術和透射電鏡(TEM)研究GH4169合金中δ相在高溫變形條件下的演變規律，分析δ相的溶解過程及其動力學機制，探討δ相對GH4169合金高溫變形動態再結晶機制的影響。
GH4169合金δ相的溶解行為及對變形機制的影響Dissolution behavior of δ phase and its effects on?deformation mechanism of GH4169 alloy
采用光學顯微鏡(OM)、掃描電鏡(SEM)、電子背散射衍射(EBSD)技術和透射電鏡(TEM)研究GH4169合金中δ相在高溫變形條件下的演變規律，分析δ相的溶解過程及其動力學機制，探討δ相對GH4169合金高溫變形動態再結晶機制的影響。結果表明：隨變形溫度的升高或應變速率的降低δ相含量減少，動態再結晶晶粒尺雨和體積含量增大，δ相主要以彎曲、扭折和切斷等方式來協調塑性變形，并在界面能降低的驅動力下由針狀逐漸轉變?yōu)槎提槧钅酥燎驙?；在高溫變形條件下，δ相的溶解時間大大縮短，位錯、空位和曲率對δ相的溶解起到重要作用，這主要與其對溶質原子擴散行為的影響有關，變形過程中產生的大量高密度位借及空位為溶質原子提供了眾多高速率擴散通道，促進了δ相的溶解；δ相的存在改變了GH4169合金的動態再結晶機制，其動態再結晶機制主要有δ相誘發動態再結晶形核和非連續動態再結晶形核。
The evolution of δ phase during hot deformation of GH4169 alloy was investigated by optical microscopy (OM), electron backscattering diffractometry (EBSD), scanning and transmitting electron microscopy. The dissolution processes of δ phase and dynamic mechanisms were analyzed. The effect of δ phase on the mechanism of dynamic recrystallization (DRX) was discussed. The results show that, with increasing deformation temperature and decreasing strain rate, the content of δ phase decreases, but the grain size and volume fraction for dynamic recrystallization increase. The plastic deformation is mainly accommodated by bending, kinking and shearing of δ phase. Under the drive force of reduced interface energy, δ phase is transformed from needle to short needle and even sphere. The accelerated dissolution of δ phase can be attributed to the effect of dislocation, vacancy and curvature, which is concerned with the diffusion behavior of solute atoms. A larger amount of high-speed channels for the diffusion of solute atoms form due to the existence of massive defects, such as high density dislocations and vacancies, promoting the dissolution of δ phase. The main nucleation mechanisms of DRX are changed to be δ phase stimulated nucleation and discontinuous nucleation due to δ phase.
以上資料由上海艾荔艾金屬材料有限公司提供，歡迎新老客戶來電洽購。
本文來自上海艾荔艾金屬材料有限公司http://m.85978597.cn，轉載請注明出處。